Product ID:X-5562 ZZ PHOS STY ALKYD EN
MSDS Date:07/07/1993
FSC:8010
NIIN:01-260-9067
MSDS Number: CCMJX

SENTRY PAINT AND CHEMICAL COMPANY

237 MILL STREET
DARBY, PA 19023
US

Emergency Phone: 800-424-9300

Info Phone: 215-522-1900

Cage: 34346

SENTRY PAINT AND CHEMICAL CO

DARBY, PA 19023 US

Cage: 34346

XYLENE (SARA 313)(CERCLA)(VP = 6.6 @ 20C)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 28.7%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYL BENZENE (SARA 313)

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 4.5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

RULE 66 VM&P NAPHTHA (VP = 40 @ 20C)

CAS: 64742-89-8

Fraction By Weight: 5.0%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

ZINC (SARA 313) (CERCLA)

CAS: 7440-66-6

RTECS: ZG8600000

Fraction By Weight: 6.0%

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION, REDNESS, TEARING,
BLURRED VISION. SKIN: DRYNESS, IRRITATION, DERMATITIS. INHALATION:
NASAL/RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, NAUSEA,
HEADACHE. INGESTION: NAUSEA, VOMITING, DIARRHEA. ASPIRATION INTO
LUNGS CAN CAUSE CHEMICAL PNEUMONITIS.
Effects of Overexposure:OVEREXPOSURE HAS BEEN FOUND TO CAUSE ENEMIA,
EYE/KIDNEY DAMAGE, LIVER/CARDIAC ABNORMALITIES.

First Aid:INHALATION: MOVE TO FRESH AIR. IF NOT BREATHING GIVE
ARTIFICIAL RESP. KEEP WARM/QUIET. GET IMMED MED AID. EYE: FLUSH
W/LARGE AMOUNTS WATER LIFTING LIDS OCCASIONALLY FOR >15 MIN. GET
MED AID. SKIN: THO ROUGHLY WASH W/SOAP & WATER. REMOVE CONTAM
CLOTHES/WASH BEFORE REUSE. INGESTION: DON'T INDUCE VOMITING. KEEP
WARM/QUIET. GET MED AID. ASPIRATION INTO LUNGS DUE TO VOMITING MAY
CAUSE CHEM PNEUMONITIS.

Flash Point Method:CC
Flash Point:55.0F,12.8C
Lower Limits:1.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL FOR SMALL FIRES. FOAM
FOR LARGE FIRES.
Fire Fighting Procedures:COOL CLOSED CONTAINERS W/WATER SPRAY NEVER
WELD/CUT ON/NEAR DRUM (EVEN EMPTY). PRODUCT/RESIDUE CAN IGNITE
EXPLOSIVELY.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY BUILD EXPLOSIVE
PRESSURE FROM HEAT.VAPORS >AIR.MAY TRAVEL ALONG GROUND/MOVE BY
VENTILATION/IGNITE AT LOCATION DISTANT FROM HANDLING POINT.

Spill Release Procedures:EVACUATE.REMOVE IGNIT SOURCES.DIKE/CONTAIN
W/INERT MATL (SAND/EARTH). TRANSFER LIQ TO COVERED METAL CNTNRS FOR
RECOVERY/DISPOSAL.REMOVE W/INERT ABSORBENT.USE NONSPARKING
TOOLS.DON'T CONTAM SEWERS/STRE AM/GROUND WATER W/SPILLED MATL OR
ABSORBENT.

Respiratory Protection:USE SCBA WHERE CONCENTRATIONS MAY BE ABOVE TLV
LIMITS. BELOW TLV, USE NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST SUFFICIENT TO KEEP AIRBORNE VAPOR
CONCENTRATION BELOW TLV LIMIT.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:EYEBATH, SAFETY SHOWER. WEAR IMPERVIOUS
CLOTHING/BOOTS TO PREVENT CHRONIC CONTACT.
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:246 TO 284F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:OLIVE DRAB PAINT, #34088

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESS HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:FUMES MAY BE HAZARDOUS.

Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, LOCAL LAWS.
INCINERATE ONLY IN EPA PERMITTED FACILITY. DON'T INCINERATE CLOSED
CONTAINER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.